if you have any question? Call Us 0086-371-60922096

Gas Boiler For Machinery Industry

Gas Fired Hot Water Boiler H6

Gas-fired steam boiler for machinery industry abnormal situation, how should we deal with it? When we use gas steam boiler, failure or abnormal phenomena it is inevitable, but in order not to affect the normal use, in the event of a problem gas steam boiler to be timely processing solutions, then the face of all kinds of circumstances, we should how to handle it? Share some of the ways we deal with unusual circumstances. If only gas steam boiler circulating pump abnormalities, such as its current decreases, the pump outlet pressure back to zero, which indicates no oil pump is idle, it may be caused by oil vaporization. Yang identify the reasons therefore first vaporized measures; such as clogging of the filter circulating pump bypass opening evacuated immediately clean the filter; heat transfer fluid as a result of added aqueous or decomposed gases are not excluded in the system, should immediately open the vent an exhaust valve. Circulation pump pressure constant, the current increases and the flow drops, deterioration of the thermally conductive fluid, the viscosity increased, should be replaced or regenerated. New heat transfer fluid as a result of decomposition of aqueous or excluded gases in the system, should immediately open the vent valve of the exhaust gas. When the current is lower than normal circulation pump, the circulation pump efficiency is decreased, the flow rate decline may be heating pipes plug fouling, stainless steel chain should be cleaned. If the gas steam boiler before and after the filter increased in pressure, the pump inlet pressure drops, the filter may be stuck, the opening of the bypass, disassemble and clean the filter. In addition to its low furnace outlet temperature liquid phase heat carrier, mainly for lack of heat fouling problems, it is timely soot blowing. Gas steam boiler grate more common problem is stuck, there are reasons including breaking grate or the grate off loose pins; coal grate has stuck to metallic inclusions; arched grate; slag is sinking the tip of the grate stuck. In response to this phenomenon, the required reverse hand grate plate debris removal, replacement breaking grate after the start, then jammed as startup, stop the rotation of the reasons detailed inspection to resolve. But also to re-adjust the adjustment screw on both sides of the grate tension, if still does not work, we need to replace the sprocket.

Some of the causes direct impact on the thermal efficiency of horizontal steam boiler for machinery industry of the country are carrying out a blaze of glory roaring coal to natural gas operations, the choice of horizontal steam boiler, greatly reducing the fine dust contaminated with dust, along with toxic gases such as nitrogen oxides emissions It has also been suppressed. Thermal efficiency is a key measure of horizontal steam boiler, a good start and that is that let you look at some of the causes direct impact on the thermal efficiency of horizontal steam boiler. Through research departments, the heat loss of horizontal steam boiler is very important from two aspects: the combustion air-fuel ratio is not satisfactory and Smoke and heat loss. Smoke and heat loss reduction should be modified in the tail horizontal steam boiler soot waste heat recycling install, or choose would be more leading series condensing boilers. Combustion air-fuel ratio over the substandard Analysis: common horizontal ejector-type steam boiler burner choice, without the formation of air-fuel ratio can be flexibly adjusted. Most of the horizontal steam boiler selected non-automatic strong emission burner, leading to the root causes of unsatisfactory air-fuel ratio has the following areas: air-fuel ratio is not ideal is more important is divided into two kinds of probability: When an excess of oxygen, there will be endless excessive cold air is heat conduction, resulting in increased energy consumption horizontal steam boilers, hot horizontal steam boiler efficiency decreased; when oxygen is not standard, incomplete combustion occurs, generating heat horizontal steam boiler efficiency decreased.

Hefei is the blue sky to win the Battle of key areas for innovation to create an international influence is of great significance. Is determined to win the battle of the blue sky, the city combined with the actual situation, formulate a three-year action plan to win the embodiment Battle of blue sky. Details are as follows.

I. Target: 2020, sulfur dioxide, total nitrogen oxide emissions were reduced over 23.1% in 2015, more than 24.2%; PM2.5 concentration decreased more than 18% in 2015, the ratio of the number of days air quality assessment requirements up to the national , severe pollution and over several days ratio decreased by more than 25% compared with 2015; the full realization of "thirteen five" binding targets.

Second, the continued implementation of the total coal consumption control. By 2020, the city's coal accounts for a further decline in the proportion of total energy consumption; the city's total coal consumption to complete the tasks assigned by the national and provincial; new coal projects to implement the reduction of coal instead.

The development of special programs, shutting down vigorously eliminate environmental protection, energy consumption, safety and other 300,000 kilowatts coal-fired units of non-compliance. For shutting down the unit's capacity, coal consumption and emissions targets, allowed to trade or replacement may be within the total national and provincial construction plan developed according to the control range, co-ordinate arrangements for the construction of ultra-low emission coal-fired capacity unit.

Third, the implementation of the "coal to gas" and "electricity instead of coal." Under the premise of the implementation of the gas source, protect people's livelihood, ceramic, glass, foundry industry to actively promote natural gas instead of coal gasification project, orderly implementation of coal-fired facilities from coal to gas. Combined with regional and industry characteristics can actively promote industrial production, building heating and cooling, transportation, agricultural production, the implementation of the residents living in five major areas "electricity instead of coal", focus on improving the proportion of final energy consumption of electricity accounted for. Of the new "coal to gas" projects, we should adhere to increase coal gas reduction to gas will change under the premise signed gas supply contracts, orderly implementation.

Fourth, to carry out comprehensive improvement of coal-fired boilers, coal-fired boilers to increase efforts to eliminate, consolidate the results of coal-fired boilers eliminated. Coal-fired boiler (with tea furnace, operating a stove, grain storage and drying equipment, coal-fired facilities) carried out an intensive investigation, one by one registration. The city basically eliminated 35 tons of steam per hour of coal-fired boilers and furnaces tea, operating the stove, grain storage and drying equipment, coal-fired facilities, no new 35 tons of steam per hour of coal-fired boilers; 35 tons of steam per hour and coal-fired boiler above (except boilers fired power plant) all meet special requirements emission limits; allowed to remain 65 tons of steam per hour coal-fired boiler and above all the complete energy transformation and ultra-low emissions within the city. County (city) district, zone one by one before the end of June 2019 to develop low-nitrogen combustion rehabilitation programs for existing gas boiler, complete combustion of low nitrogen transformation in this area of ​​existing gas boiler before the end of 2019 more than 50%, before the end of 2020 transformation is substantially complete; after transformation principle NOx emission is not higher than 50 mg / m, and comply with appropriate safety boiler specification. Urban built-up area of ​​ultra-low emission biomass boilers implement reform.

How to prevent corrosion of the gas boiler for machinery industry gas boiler it if the temperature is too high, some of the components of the boiler working long hours in the intense heat of the environment at work, the situation will cause boiler corrosion occurs. So, we are in the process of work what to do to reduce the corrosion of it? Here to tell you about some of the methods of preventing corrosion of boiler gas. Reason and approach demands on internal corrosion of the gas boiler must be in accordance with the methods and principles of conduct, you can now use a more extensive domestic and international gas boiler corrosion detection approach is magnetic flux leakage and ultrasonic detection. Ultrasonic Ultrasonic detection is used to measure the wall thickness after etching using the principle of ultrasonic pulse reflection. The basic principle of magnetic flux leakage method leakage flux detection method is based on the high-permeability properties of the ferromagnetic materials, magnetic permeability of the gas boiler corrosion disadvantage is much less than the permeability of the furnace, the applied gas boiler is magnetized in a magnetic field effect, when the furnace is no disadvantage, most of the magnetic lines of force through the pipe. Uniform distribution of lines of magnetic force at the moment; when the internal elbow has the disadvantage that the onset of meander lines of magnetic force, and a part of magnetic lines of force from leaking out of the outer steel pipe. Detecting the escaping magnetic flux leakage outer elbow, it can be determined whether the shortcomings exist. When the probe detects a straight guide hot oil furnace inner wall emit ultrasound pulse, to receive from the probe first reflected pulse within the outer wall, and will receive the ultrasound probe, this pulse and the pulse reflected from the outer wall of the outer appearance of the reflected pulse trip distance between the reflecting wall thickness. Gas-fired boiler in accordance with the practices and conditions set forth in the demand for the detection of practice, in accordance with the detection of ultrasonic inspection method can be distinguished way. High temperature components such as a gas boiler front panel, convection superheater and reheater temperature is the primary structural member and the like inside the boiler, a very long time to work in the harsh environment of use of the medium flame, smoke, ash, etc., and therefore the working process changes occurred in the organization and function of a range of materials, these changes hit the gas boiler creep, fatigue, corrosion, erosion and other messy aging and failure mechanisms. These high temperatures Microstructure component material will follow the extension of working time deteriorated creep damage occurs, such as loose pearlite, spheroidized carbides, grain boundary and growth mobilization, holes creep, intergranular cracking occurs .

Food Machinery Industry Biomass Steam Generator

Quality Gas Steam Boiler manufacturers amp; exporter - buy Food Machinery Industry Biomass Steam Generator 170 Rated Steam Temperature from China manufacturer.

Get a Quote

China Gas Boiler manufacturer, Wall Hung Gas Boiler,

China Gas Boiler supplier, Wall Hung Gas Boiler, Gas Wall-Mounted Boiler Manufacturers/ Suppliers - Foshan City Shunde District Xuzheng Industrial Co., Ltd.

Get a Quote

Boiler | Paper machinery-paper making machine,paper

Gas/Oil Boiler Steam Boiler is a necessary Auxiliary Equipments for a paper mill, there are coal fired boiler and gas/oil fired boiler. It is for supplying the steam

Get a Quote

Steam Boiler in Food Industry : Uses amp; Manufacturers

Steam Boiler in Food Industry. Heat is a heart of industrial food processes. The food industry needs heat at every stage of the process. Direct heat or heat from the hot water is an essential factor of food processing industry. Inside the beverage business, steam is used for cooking, drying, and warming, and for general utilize-cleaning.

Get a Quote

Beijing Double Dragon International Industrial amp;

Quality biomass boiler for sale, biomass boiler amp; oilgas fired boiler provided by China Suppliers - Beijing Double Dragon International Industrial amp; Mining Machinery Co., Ltd..

Get a Quote

Boiler | Paper machinery-paper making machine,paper

Gas/Oil Boiler Steam Boiler is a necessary Auxiliary Equipments for a paper mill, there are coal fired boiler and gas/oil fired boiler. It is for supplying the steam

Get a Quote

Gas 50kg~500kg Customized Road Curing/Concrete

Oil Steam Boiler, Gas Steam Boiler, Boiler manufacturer / supplier in China, offering Gas 50kg~500kg Customized Road Curing/Concrete Curing/Oil Fired Industry Steam Boiler, Diesel Steam Wash Machine Door to Door Service, Diesel Steam Car Washing Machine and so on.

Get a Quote

Food Machinery Industry Biomass Steam Generator

Quality Gas Steam Boiler manufacturers amp; exporter - buy Food Machinery Industry Biomass Steam Generator 170 Rated Steam Temperature from China manufacturer.

Get a Quote

Food Machinery Industry Biomass Steam Generator

Quality Gas Steam Boiler manufacturers amp; exporter - buy Food Machinery Industry Biomass Steam Generator 170 Rated Steam Temperature from China manufacturer.

Get a Quote

steam boiler used in food production machinery

steam boiler used in food production machinery industry Quick inquiry: I need the quotation of Electric Boiler steam boiler hot water boiler Hot Air Boiler Thermal oil Boiler, the fuel is, the pressure is, this capacity is, My Name is, my Email is, my phone number is, Please Send the detail information for me!

Get a Quote

Shenghui Machinery (CSM) | cement machinery,cement

2014-4-16·Apart from the application in cement industry, this series pulse jet dust filter can be applied to metallurgy industry, chemical industry, machinery industry, civil boiler industry, etc. for dust collection of flue gas.

Get a Quote

Prettech Machinery Making Co., Ltd. Taian City

Taishan Group is a large stock-owed enterprise of state standrad With Taishan Boiler Factory Its key unit. It is also one of the 500 biggest machinery industry with best economic benifits, located at the foot of the world-famous Mt. Tai.

Get a Quote

China Shanghai Supplier Quality 0.3t 0.5t/H Gas Boiler

Boiler, Electric Boiler, Portable Generator manufacturer / supplier in China, offering Shanghai Supplier Quality 0.3t 0.5t/H Gas Boiler, Steam Boiler for Alcohol Distillation 500kg/Hr Diesel Fired Steam Boiler, 500kg/H Gas Fuel Steam Boiler for Yarn Dyeing Machine Yano Boiler and so on.

Get a Quote

China 300kg/H Gas and Oil Fired Steam Generator

Boiler, Steam Boiler, Gas Fired Steam Boiler manufacturer / supplier in China, offering 300kg/H Gas and Oil Fired Steam Generator Boiler, China Quick Loading Steam Capacity 65 Kg/Hr Small Electric Steam Boilers, High-Precision and Fast Handheld Infrared Thermometer for Measuring Body

Get a Quote

Boiler-Steam Generator Jiangxin Boiler Co.,Ltd

2019-10-26·Shangrao Jiangxin Boiler Co., Ltd. is a B-class boiler manufacturer integrating design, manufacture, processing, sales and service. At present, there are nearly 150 kinds of boiler products in various series such as biomass boiler, fuel (gas) boiler

Get a Quote

Related Information

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!

Online Chat